卡特故障代码
燃油温度传感器或线路故障|挖掘机维修,挖掘机修理,维修挖掘机,修理挖掘机174-04 174-04 Fuel Temperature short to ground 燃油温度传感器或线路故障16 626-05 2417-05 Ether Injection Control Solenoid open/short to +batt
乙醚喷射控制电磁阀或线路故障
626-06 2417-06 Ether Injection Control Solenoid short to ground
乙醚喷射控制电磁阀或线路故障
21 678-03 41-03 8 Volt DC Supply short to +batt
8V直流电源故障
678-04 41-04 8 Volt DC Supply short to ground
8V直流电源故障
620-03 262-03 5 Volt Sensor DC Power Supply short to +batt
5V直流电源故障
1079-03
620-04 262-04 5 Volt Sensor DC Power Supply short to ground
5V直流电源故障
1079-04
24 100-03 100-03 Engine Oil Pressure open/short to +batt
机油压力传感器或线路故障
100-04 100-04 Engine Oil Pressure short to ground
机油压力传感器或线路故障
100-10 100-10 Engine Oil Pressure abnormal rate of change
机油压力更新率不正常
25 102-03 102-03 Boost Pressure Sensor short to +batt
增压压力传感器或线路故障
102-04 102-04 Boost Pressure Sensor short to ground
增压压力传感器或线路故障
102-10 102-10 Boost Pressure Sensor abnormal rate of change
增压压力更新率不正常
102-03 1785-03 Intake Manifold Pressure Sensor voltage above normal
进气压力传感器电压高于正常值
102-04 1785-04 Intake Manifold Pressure Sensor voltage below normal
进气压力传感器电压低于正常值
102-10 1785-10 Intake Manifold Pressure Sensor abnormal rate of change
进气压力更新率不正常
26 108-03 274-03 Atmospheric Pressure open/short to +batt
大气压力传感器或线路故障
108-04 274-04 Atmospheric Pressure short to ground
大气压力传感器或线路故障
27 110-03 110-03 Engine Coolant Temperature open/short to +batt
冷却液温度传感器或线路故障
110-04 110-04 Engine Coolant Temperature short to ground
冷却液温度传感器或线路产
28 91-13 91-13 Throttle Position calibration required
油门需要校准
32 91-08 91-08 Throttle Position signal abnormal
油门信号不正常
34 190-08 190-08 Engine Speed signal abnormal
91免费黄色软件转速信号不正常
723-08 342-08 Secondary Engine Speed signal abnormal
备用91免费黄色软件转速信号不正常
35 190-15 E362 (1) Engine Overspeed Warning
91免费黄色软件超速报警
190-00 E362 (3) Engine Overspeed Shutdown
91免费黄色软件超速停机
37 94-03 94-03 Fuel Pressure open/short to +batt
燃油压力传感器或线路故障
94-04 94-04 Fuel Pressure short to ground
燃油压力传感器或线路故障
38 105-03 172-03 Intake Manifold Air Temp open/short to +batt
进气温度传感器或线路故障
105-04 172-04 Intake Manifold Air Temp short to ground
进气温度传感器或线路故障
42 637-13 261-13 Engine Timing calibration required
91免费黄色软件正时需校准
46 100-17 E360 (1) Low Engine Oil Pressure Warning
机油压力低报警
100-18 E360 (2) Low Engine Oil Pressure Derate
机油压力低降载
100-01 E360 (3) Low Engine Oil Pressure Shutdown
机油压力低停机
51 168-00 168-00 System Voltage high
系统电压高
168-01 168-01 System Voltage low
系统电压低
168-02 168-02 System Voltage intermittent/erratic
系统电压不正常
56 630-02 268-02 Check Programmable Parameters
91免费黄色软件参数设置需检查
58 639-09 247-09 J1939 Data Link communications
J1939数据链接故障
61 110-15 E361 (1) High Engine Coolant Temperature Warning
冷却液温度高报警
110-16 E361 (2) High Engine Coolant Temperature Derate
冷却液温度高降载
110-00 E361 (3) High Engine Coolant Temperature Shutdown
冷却液温度高停机
62 111-17 E2143 (1) Low Engine Coolant Level Warning
冷却液位低报警
111-18 E2143 (2) Low Engine Coolant Level Derate
冷却液位低降载
111-01 E2143 (3) Low Engine Coolant Level Shutdown
冷却液位低停机
63 94-15 E096 (1) High Fuel Pressure Warning
燃油压力高报警
64 1636-15 E539 (1) High Inlet Air Temperature Warning
进气温度高报警
1636-00 E539 (3) High Inlet Air Temperature Shutdown
进气温度高停机
65 174-15 E363 (1) High Fuel Temperature Warning
燃油温度高报警
174-16 E363 (2) High Fuel Temperature Derate
燃油温度高降载
174-00 E363 (3) High Fuel Temperature Shutdown
燃油温度高停机
67 0441-15 E445 (1) High Auxiliary Temperature Warning
辅助温度高报警
0441-16 E445 (2) High Auxiliary Temperature Derate
辅助温度高降载
0441-00 E445 (3) High Auxiliary Temperature Shutdown
辅助温度高停机
0441-03 1836-03 Auxiliary Temperature Sensor open/short to +batt
辅助温度传感器或线路故障
0441-04 1836-04 Auxiliary Temperature Sensor short to ground
辅助温度传感器或线路故障
68 1387-15 E443 (1) High Auxiliary Pressure Warning
辅助压力高报警
1387-16 E443 (2) High Auxiliary Pressure Derate
辅助压力高降载
1387-00 E443 (3) High Auxiliary Pressure Shutdown
辅助压力高停机
1387-03 1835-03 Auxiliary Pressure Sensor open/short to +batt
辅助压力传感器或线路故障
1387-04 1835-04 Auxiliary Pressure Sensor short to ground
辅助压力传感器或线路故障
71 651-05 001-05 Cylinder #1 Injector open circuit
1缸喷油器故障
651-06 001-06 Cylinder #1 Injector short
1缸喷油器故障
72 652-05 002-05 Cylinder #2 Injector open circuit
2缸喷油器故障
652-06 002-06 Cylinder #2 Injector short
2缸喷油器故障
73 653-05 003-05 Cylinder #3 Injector open circuit
3缸喷油器故障
653-06 003-06 Cylinder #3 Injector short
3缸喷油器故障
74 654-05 004-05 Cylinder #4 Injector open circuit
4缸喷油器故障
654-06 004-06 Cylinder #4 Injector short
4缸喷油器故障
75 655-05 005-05 Cylinder #5 Injector open circuit
5缸喷油器故障
655-06 005-06 Cylinder #5 Injector short
5缸喷油器故障
76 656-05 006-05 Cylinder #6 Injector open circuit
6缸喷油器故障
656-06 006-06 Cylinder #6 Injector short
6缸喷油器故障挖掘机技术故障与师傅进行沟通交流，官方网站http://www.hnwhhj.com修理直拨:0551-64493367 服务专线:13956953738
乙醚喷射控制电磁阀或线路故障
626-06 2417-06 Ether Injection Control Solenoid short to ground
乙醚喷射控制电磁阀或线路故障
21 678-03 41-03 8 Volt DC Supply short to +batt
8V直流电源故障
678-04 41-04 8 Volt DC Supply short to ground
8V直流电源故障
620-03 262-03 5 Volt Sensor DC Power Supply short to +batt
5V直流电源故障
1079-03
620-04 262-04 5 Volt Sensor DC Power Supply short to ground
5V直流电源故障
1079-04
24 100-03 100-03 Engine Oil Pressure open/short to +batt
机油压力传感器或线路故障
100-04 100-04 Engine Oil Pressure short to ground
机油压力传感器或线路故障
100-10 100-10 Engine Oil Pressure abnormal rate of change
机油压力更新率不正常
25 102-03 102-03 Boost Pressure Sensor short to +batt
增压压力传感器或线路故障
102-04 102-04 Boost Pressure Sensor short to ground
增压压力传感器或线路故障
102-10 102-10 Boost Pressure Sensor abnormal rate of change
增压压力更新率不正常
102-03 1785-03 Intake Manifold Pressure Sensor voltage above normal
进气压力传感器电压高于正常值
102-04 1785-04 Intake Manifold Pressure Sensor voltage below normal
进气压力传感器电压低于正常值
102-10 1785-10 Intake Manifold Pressure Sensor abnormal rate of change
进气压力更新率不正常
26 108-03 274-03 Atmospheric Pressure open/short to +batt
大气压力传感器或线路故障
108-04 274-04 Atmospheric Pressure short to ground
大气压力传感器或线路故障
27 110-03 110-03 Engine Coolant Temperature open/short to +batt
冷却液温度传感器或线路故障
110-04 110-04 Engine Coolant Temperature short to ground
冷却液温度传感器或线路产
28 91-13 91-13 Throttle Position calibration required
油门需要校准
32 91-08 91-08 Throttle Position signal abnormal
油门信号不正常
34 190-08 190-08 Engine Speed signal abnormal
91免费黄色软件转速信号不正常
723-08 342-08 Secondary Engine Speed signal abnormal
备用91免费黄色软件转速信号不正常
35 190-15 E362 (1) Engine Overspeed Warning
91免费黄色软件超速报警
190-00 E362 (3) Engine Overspeed Shutdown
91免费黄色软件超速停机
37 94-03 94-03 Fuel Pressure open/short to +batt
燃油压力传感器或线路故障
94-04 94-04 Fuel Pressure short to ground
燃油压力传感器或线路故障
38 105-03 172-03 Intake Manifold Air Temp open/short to +batt
进气温度传感器或线路故障
105-04 172-04 Intake Manifold Air Temp short to ground
进气温度传感器或线路故障
42 637-13 261-13 Engine Timing calibration required
91免费黄色软件正时需校准
46 100-17 E360 (1) Low Engine Oil Pressure Warning
机油压力低报警
100-18 E360 (2) Low Engine Oil Pressure Derate
机油压力低降载
100-01 E360 (3) Low Engine Oil Pressure Shutdown
机油压力低停机
51 168-00 168-00 System Voltage high
系统电压高
168-01 168-01 System Voltage low
系统电压低
168-02 168-02 System Voltage intermittent/erratic
系统电压不正常
56 630-02 268-02 Check Programmable Parameters
91免费黄色软件参数设置需检查
58 639-09 247-09 J1939 Data Link communications
J1939数据链接故障
61 110-15 E361 (1) High Engine Coolant Temperature Warning
冷却液温度高报警
110-16 E361 (2) High Engine Coolant Temperature Derate
冷却液温度高降载
110-00 E361 (3) High Engine Coolant Temperature Shutdown
冷却液温度高停机
62 111-17 E2143 (1) Low Engine Coolant Level Warning
冷却液位低报警
111-18 E2143 (2) Low Engine Coolant Level Derate
冷却液位低降载
111-01 E2143 (3) Low Engine Coolant Level Shutdown
冷却液位低停机
63 94-15 E096 (1) High Fuel Pressure Warning
燃油压力高报警
64 1636-15 E539 (1) High Inlet Air Temperature Warning
进气温度高报警
1636-00 E539 (3) High Inlet Air Temperature Shutdown
进气温度高停机
65 174-15 E363 (1) High Fuel Temperature Warning
燃油温度高报警
174-16 E363 (2) High Fuel Temperature Derate
燃油温度高降载
174-00 E363 (3) High Fuel Temperature Shutdown
燃油温度高停机
67 0441-15 E445 (1) High Auxiliary Temperature Warning
辅助温度高报警
0441-16 E445 (2) High Auxiliary Temperature Derate
辅助温度高降载
0441-00 E445 (3) High Auxiliary Temperature Shutdown
辅助温度高停机
0441-03 1836-03 Auxiliary Temperature Sensor open/short to +batt
辅助温度传感器或线路故障
0441-04 1836-04 Auxiliary Temperature Sensor short to ground
辅助温度传感器或线路故障
68 1387-15 E443 (1) High Auxiliary Pressure Warning
辅助压力高报警
1387-16 E443 (2) High Auxiliary Pressure Derate
辅助压力高降载
1387-00 E443 (3) High Auxiliary Pressure Shutdown
辅助压力高停机
1387-03 1835-03 Auxiliary Pressure Sensor open/short to +batt
辅助压力传感器或线路故障
1387-04 1835-04 Auxiliary Pressure Sensor short to ground
辅助压力传感器或线路故障
71 651-05 001-05 Cylinder #1 Injector open circuit
1缸喷油器故障
651-06 001-06 Cylinder #1 Injector short
1缸喷油器故障
72 652-05 002-05 Cylinder #2 Injector open circuit
2缸喷油器故障
652-06 002-06 Cylinder #2 Injector short
2缸喷油器故障
73 653-05 003-05 Cylinder #3 Injector open circuit
3缸喷油器故障
653-06 003-06 Cylinder #3 Injector short
3缸喷油器故障
74 654-05 004-05 Cylinder #4 Injector open circuit
4缸喷油器故障
654-06 004-06 Cylinder #4 Injector short
4缸喷油器故障
75 655-05 005-05 Cylinder #5 Injector open circuit
5缸喷油器故障
655-06 005-06 Cylinder #5 Injector short
5缸喷油器故障
76 656-05 006-05 Cylinder #6 Injector open circuit
6缸喷油器故障
656-06 006-06 Cylinder #6 Injector short
6缸喷油器故障挖掘机技术故障与师傅进行沟通交流，官方网站http://www.hnwhhj.com修理直拨:0551-64493367 服务专线:13956953738
